流量开关
1流量开关种类
第一、挡板式流量开关
又称为机械式流量开关,通常安装在水泵出水口到设备出水口的这段管路中,允许水平和垂直安装。挡板式流量开关的机械部分与电子部分安全隔离,不含有容易导致故障的波纹管,而且其电器部件不与温差大的金属部件直接接触,可有效避免电器部件产生冷凝水导致锈蚀的情况,并且其断开和复位流量较小。挡板式流量开关可广泛用于工业自动化、机械设备、空气压缩工业、制冷及空调领域,工业场合主要应用于激光设备冷却系统、水冷焊机、电炉、真空镀膜机、多晶硅铸锭炉等。
第二、热式流量开关
又称为电子式流量开关,是利用探测头温度变化的原理设计的。可用于监控管道内流体的流速大小、断流监测或防止泵的空转。
第三、压差式流量开关
压差开关用作HVAC中的流量控制,具有准确控制流量,对水系统不再额外增加阻力,对水管管径无要求以及无水流扰动干扰等特性,可取代任何形式的靶式流量开关,相对于靶式流量开关又可以避免由水泵气蚀引起的假流量,并且拥有准确的复位流量和断开流量。可广泛应用于使用板式换热器、套管式换热器和壳管式换热器的大、中、小型风冷或水冷冷水机组中作为水流量控制以及水泵、水过滤器状态的监控。
2流量开关工作原理
流量开关的探头内置有发热模块和感热模块,因此,流量开关的热传导与介质的流速密切相关。在测量时,发热模块会发出热量,如果管道内没有介质流动,那么感热模块接收到的热量将会是一个固定值,当有介质流动时,感热模块所接收到的热量则会随着介质的流速变化而变化,感热模块会将温差信号转化成电信号,再通过处理器将其转换为对应的标准模拟量信号或接点信号输出。
3流量开关安装注意事项
第一、流量开关出厂调节在最小流量值附近,在使用时不能调到低于出厂设定的位置,以免导致开关无法恢复到“无液流”的位置。
第二、如果需要调高流量值,应该沿着顺时钟方向旋转调节螺丝。在调高出厂设定值后若需要调低流量值,可以沿着逆时钟方向旋转调节螺丝。
第三、调节结束后,检查流量开关的设定值是否不低于出厂设定值,按动主杠杆数次,检查主杠杆回复时开关是否有“咔嗒”声,如果没有,应沿着顺时钟方向旋转调节螺丝直至杠杆回复时发出“咔嗒”声。
第四、封漆的设定螺丝不可调节。否则一旦变动便会破坏流量开关的控制或造成调节失效而无法工作。
第五、如果流量调节过高,在低流量时将无法带动流向片,开关无法动作。如果流量调节过低,开关会过于灵敏从而产生误动作。
4氟树脂涂料缺点
氟树脂涂料虽然有良好的综合性能,但是也有以下不完美的地方。
油性氟树脂涂料缺点:
(1) 对外墙施工条件和配套材料要求高,双组分涂料施工存在多项限制。
(2) 氟树脂涂料涂层偏向刚性,没有良好的弹性,性能不稳定。
(3) 造价高,长期装饰效果一般。
(4) 含有大量的有机挥发物,对环境有污染。
水性氟树脂涂料缺点:
(1) 在分解温度下为无毒状态,受热分解会产生十几种有害气体。
(2) 保光性和硬度都较差。
5衣柜拉手安装
衣柜拉手安装:将拉手的专用螺丝杆从门板背面拉手孔插入门板正面,露出丝杆,然后将拉手丝孔对准门板正面露出的丝杆,用螺丝刀将拉手通过丝杆与门板锁紧。
衣柜拉手安装的位置有一定讲究。像一组大衣柜,上部的拉手应该装在门的下角,下部的拉手应该装在门的上角。这不仅是为了符合人体工程学的规范要求,也是为了视觉上的形式美。
6气动阀门检测
气动阀门不能正常打开、关闭情况下的各项检测。
1.检验电磁阀是否正常,线圈是否耗损或接触不良,电磁阀的阀芯是否被东西卡死
维修方法:更换线圈,清理电磁阀上卡住的东西,以上方法没用就更换电磁阀。
2.单边供气检验气动执行器,查看是否正常工作,如气缸活塞窜气、缸体与端盖或转轴处漏气等
维修方法:拆开执行器检查密封件是否已损坏,气缸内孔表面是否已损坏。更换已坏密封圈、更换活塞、或气缸。
3.检查阀内是否有东西将球芯或阀板卡住
维修方法:清理杂质或者更换已损阀件。
4.检查手动操作执行机构的手柄是否处在手动位置
处理方法:将手柄扳到气动自动位置。
5.检查管路是否扭曲、压扁
处理方法:纠正或更换管路。
6.检查介质或环境温度是否太低,造成管路冻结
处理方法:即时清除冷凝水,增设除水设备。
7 厨房水槽漏水
厨房水槽出现漏水现象,需要对原因进行分析,当然问题产生的原因可能不是唯一的,我们应该具体问题具体分析,根据不同的情况来修理。
情况一:水龙头漏水
将水龙头红色及蓝色的标志拆开,并更换其中的橡胶垫即可。
情况二:水槽和台面间的衔接松动,积水溺到台面,并漏到橱柜里
买好玻璃胶条,并将玻璃胶密封于水槽和台面间的衔接处。
情况三:厨房水槽下水管漏水
无论是上面的接口漏水,还是水槽下水管与地下的下水管间漏水,问题均出在橡胶垫上,橡胶垫老化或是开裂,都会出现漏水,这时只需把这个橡胶垫拆开并更换一个便可。
情况四:水槽本身漏水
用防水腻子涂抹水槽漏水处。
情况五:水槽零件坏或松动
先仔细检查角阀、螺丝和胶垫等位置,看是不是因使用太久,出现腐蚀和老化问题,若是如此,建议重新更换一个。
8厨房水槽堵了怎么办
如果发现厨房水槽堵了,不要急着去用水冲掉杂质或者把管道拆开。首先要做的就是把水管关闭,不然会造成更多的积水。然后再检查是哪个部位堵塞,或者是什么东西堵塞。厨房水槽一般堵塞的地方是U型管道处,因为堆积杂物导致排水不顺畅。或者是带排污螺丝的下水管道。弄清楚之后,在排水管下面垫一个污水盆。然后拆卸管道,用可以疏通的东西两边疏通一下。如果还有杂物,则将所有的连接口全部拧开卸下,冲洗干净。然后再组装回去。
值得注意的一点小技巧,厨房水槽下水管经常是被油腻杂物,菜渣堵塞,疏通前,可先往下水管导入一壶开水,然后用胶皮管子/钩子等伸到下水管中,清除杂物。
清理方法:准备一条胶皮管子,不用太长,只要能连通自来水笼头和下水管道就行。将管子的一端插入下水管道口,周围用破旧抹布或毛巾塞紧,将水管另一段固定到自来水管上,然后将水笼头开到最大,冲两三分钟,下水管道就能疏通了,堵的比较厉害,用手摇管道疏通器进行疏通:先将逆时针方向拧动止旋螺钉,然后将弹簧拉出放到下水管中,一直顶到障碍物,然后拉出10公分左右弹簧,拧紧止旋螺钉,选装把手,并施加压力,当完全进去后,在松开止旋螺钉,再拉出10公分弹簧反复操作直到感觉转动把手很轻松时,缓慢拉起就解决问题了。
转载原文地址:https://baike.tobosu.com/view/n19506.html
转载原文地址:https://baike.tobosu.com/view/n5329.html
转载原文地址:https://baike.tobosu.com/view/n5801.html
转载原文地址:https://baike.tobosu.com/view/n2780.html
转载原文地址:https://baike.tobosu.com/view/n22205.html
转载原文地址:https://baike.tobosu.com/view/n4908.html
转载原文地址:https://baike.tobosu.com/view/n16587.html
转载原文地址:https://baike.tobosu.com/view/n22452.html
转载原文地址:https://baike.tobosu.com/view/n1213.html
转载原文地址:https://baike.tobosu.com/view/n2346.html
转载原文地址:https://baike.tobosu.com/view/n3412.html
转载原文地址:https://baike.tobosu.com/view/n1827.html
转载原文地址:https://baike.tobosu.com/view/n19563.html
转载原文地址:https://baike.tobosu.com/view/n6578.html
转载原文地址:https://baike.tobosu.com/view/n19432.html
转载原文地址:https://baike.tobosu.com/view/n19446.html
转载原文地址:https://baike.tobosu.com/view/n2535.html
转载原文地址:https://baike.tobosu.com/view/n3852.html
转载原文地址:https://baike.tobosu.com/view/n17644.html
转载原文地址:https://baike.tobosu.com/view/n17618.html
转载原文地址:https://baike.tobosu.com/view/n1179.html
转载原文地址:https://baike.tobosu.com/view/n22245.html
转载原文地址:https://baike.tobosu.com/view/n2270.html
转载原文地址:https://baike.tobosu.com/view/n16464.html
转载原文地址:https://baike.tobosu.com/view/n19406.html
转载原文地址:https://baike.tobosu.com/view/n2675.html
转载原文地址:https://baike.tobosu.com/view/n6622.html
转载原文地址:https://baike.tobosu.com/view/n21989.html
转载原文地址:https://baike.tobosu.com/view/n2191.html
转载原文地址:https://baike.tobosu.com/view/n18562.html
转载原文地址:https://baike.tobosu.com/view/n5580.html
转载原文地址:https://baike.tobosu.com/view/n4154.html
转载原文地址:https://baike.tobosu.com/view/n4634.html
转载原文地址:https://baike.tobosu.com/view/n17010.html
转载原文地址:https://baike.tobosu.com/view/n18543.html
转载原文地址:https://baike.tobosu.com/view/n19577.html
转载原文地址:https://baike.tobosu.com/view/n6371.html
转载原文地址:https://baike.tobosu.com/view/n1425.html
转载原文地址:https://baike.tobosu.com/view/n17118.html
转载原文地址:https://baike.tobosu.com/view/n16854.html
转载原文地址:https://baike.tobosu.com/view/n17516.html
转载原文地址:https://baike.tobosu.com/view/n16447.html
转载原文地址:https://baike.tobosu.com/view/n5611.html
转载原文地址:https://baike.tobosu.com/view/n2786.html
转载原文地址:https://baike.tobosu.com/view/n1664.html
转载原文地址:https://baike.tobosu.com/view/n22440.html
转载原文地址:https://baike.tobosu.com/view/n3023.html
转载原文地址:https://baike.tobosu.com/view/n18392.html
转载原文地址:https://baike.tobosu.com/view/n22371.html
转载原文地址:https://baike.tobosu.com/view/n5378.html
转载原文地址:https://baike.tobosu.com/view/n5572.html
转载原文地址:https://baike.tobosu.com/view/n19411.html
转载原文地址:https://baike.tobosu.com/view/n19447.html
转载原文地址:https://baike.tobosu.com/view/n2487.html
转载原文地址:https://baike.tobosu.com/view/n1422.html
转载原文地址:https://baike.tobosu.com/view/n5614.html
转载原文地址:https://baike.tobosu.com/view/n22299.html
转载原文地址:https://baike.tobosu.com/view/n1407.html
转载原文地址:https://baike.tobosu.com/view/n20917.html
转载原文地址:https://baike.tobosu.com/view/n5578.html
转载原文地址:https://baike.tobosu.com/view/n21997.html
转载原文地址:https://baike.tobosu.com/view/n1772.html
转载原文地址:https://baike.tobosu.com/view/n3406.html
转载原文地址:https://baike.tobosu.com/view/n5795.html
转载原文地址:https://baike.tobosu.com/view/n4022.html
转载原文地址:https://baike.tobosu.com/view/n15157.html
转载原文地址:https://baike.tobosu.com/view/n1319.html
转载原文地址:https://baike.tobosu.com/view/n1802.html
转载原文地址:https://baike.tobosu.com/view/n21895.html
转载原文地址:https://baike.tobosu.com/view/n2991.html
转载原文地址:https://baike.tobosu.com/view/n19430.html
转载原文地址:https://baike.tobosu.com/view/n4913.html
转载原文地址:https://baike.tobosu.com/view/n21608.html
转载原文地址:https://baike.tobosu.com/view/n173.html
转载原文地址:https://baike.tobosu.com/view/n4841.html
转载原文地址:https://baike.tobosu.com/view/n3523.html
转载原文地址:https://baike.tobosu.com/view/n22454.html
转载原文地址:https://baike.tobosu.com/view/n16863.html
转载原文地址:https://baike.tobosu.com/view/n17290.html
转载原文地址:https://baike.tobosu.com/view/n3936.html
转载原文地址:https://baike.tobosu.com/view/n16416.html
转载原文地址:https://baike.tobosu.com/view/n4546.html
转载原文地址:https://baike.tobosu.com/view/n17536.html
转载原文地址:https://baike.tobosu.com/view/n6571.html
转载原文地址:https://baike.tobosu.com/view/n19588.html
转载原文地址:https://baike.tobosu.com/view/n2075.html
转载原文地址:https://baike.tobosu.com/view/n5485.html
转载原文地址:https://baike.tobosu.com/view/n4295.html
转载原文地址:https://baike.tobosu.com/view/n57.html
转载原文地址:https://baike.tobosu.com/view/n4871.html
转载原文地址:https://baike.tobosu.com/view/n17554.html
转载原文地址:https://baike.tobosu.com/view/n3524.html
转载原文地址:https://baike.tobosu.com/view/n4541.html
转载原文地址:https://baike.tobosu.com/view/n4482.html
转载原文地址:https://baike.tobosu.com/view/n2597.html
转载原文地址:https://baike.tobosu.com/view/n22070.html
转载原文地址:https://baike.tobosu.com/view/n2772.html
转载原文地址:https://baike.tobosu.com/view/n19221.html
转载原文地址:https://baike.tobosu.com/view/n3469.html
转载原文地址:https://baike.tobosu.com/view/n6670.html
转载原文地址:https://baike.tobosu.com/view/n21700.html
转载原文地址:https://baike.tobosu.com/view/n20472.html
转载原文地址:https://baike.tobosu.com/view/n22071.html
转载原文地址:https://baike.tobosu.com/view/n4200.html
转载原文地址:https://baike.tobosu.com/view/n2499.html
转载原文地址:https://baike.tobosu.com/view/n3976.html
转载原文地址:https://baike.tobosu.com/view/n20395.html
转载原文地址:https://baike.tobosu.com/view/n5020.html
转载原文地址:https://baike.tobosu.com/view/n22271.html
转载原文地址:https://baike.tobosu.com/view/n2509.html
转载原文地址:https://baike.tobosu.com/view/n22054.html
转载原文地址:https://baike.tobosu.com/view/n2688.html
转载原文地址:https://baike.tobosu.com/view/n17364.html
转载原文地址:https://baike.tobosu.com/view/n5067.html
转载原文地址:https://baike.tobosu.com/view/n2602.html
转载原文地址:https://baike.tobosu.com/view/n2490.html
转载原文地址:https://baike.tobosu.com/view/n16853.html
转载原文地址:https://baike.tobosu.com/view/n16527.html
转载原文地址:https://baike.tobosu.com/view/n1588.html
转载原文地址:https://baike.tobosu.com/view/n17688.html
转载原文地址:https://baike.tobosu.com/view/n1069.html
转载原文地址:https://baike.tobosu.com/view/n22503.html
转载原文地址:https://baike.tobosu.com/view/n5189.html
转载原文地址:https://baike.tobosu.com/view/n3172.html
转载原文地址:https://baike.tobosu.com/view/n16226.html
转载原文地址:https://baike.tobosu.com/view/n3837.html
转载原文地址:https://baike.tobosu.com/view/n2888.html
转载原文地址:https://baike.tobosu.com/view/n1485.html
转载原文地址:https://baike.tobosu.com/view/n18373.html
转载原文地址:https://baike.tobosu.com/view/n21462.html
转载原文地址:https://baike.tobosu.com/view/n5081.html
转载原文地址:https://baike.tobosu.com/view/n5181.html
转载原文地址:https://baike.tobosu.com/view/n462.html
上述内容来自用户自行上传或互联网,如有版权问题,请联系zxcq@corp.to8to.com 。